Cummins L423D Diesel Engine 60 HP 4 cyl, Generator etc

Up

For sale is a Cummins engine. It is a four cylinder engine labeled L423D P 50049F, serial number 0053124085. According to this page that I pulled off the net, this engine is a 60 HP engine at 2600 RPM.

It came to me from a Great Lakes military base. It was in a sealed crate. The engine is used, but appears to not have signs of prolonged use (not too much soot in the exhaust manifold, a lot of original paint still there). There is some rust on the bare metal mating surface (where a shaft attaches to the engine flywheel).

Upon inspection, the engine was found to have the following:

• Radiator
• Fuel pump
• Electric Injector fuel turn on valve
• Engine block heater 110VAC with regular household plug
• Splined shaft hole
• Starter
• Oil Pressure Switch
• Overtemperature switch
• Governor that can either be preset for a given speed, or else controlled mechanically via a lever or whatever.

Based on my experience with my Onan DJE Diesel Generator, I tried to start it as follows.

• Connected a battery negative to engine ground
• I energized the fuel valve via 12V
• Connected the starter to the battery
• Put water into radiator
• Cranked a little to get water into engine block
• Heated block with the heater (5 min)
• Started cranking and blew hot air into the intake using a propane torch

That got the engine started. It purred for about a minute "hunting" for a good speed. Finally it settled at some idle speed and ran.

Note on videos

On the videos, for some reason, the sound "cuts out" at some point during the video. It is the fault of my camera, the engine does not stop when you stop hearing sound.